|
|
Note for company road test
Post by HuaBeiLang
Note for company road test:
// For coupling and do inspection, the tractor is separated with the trailer at the begining.
// as one guy said, sinoquebec from YIN BA Jia Xiao did not know coupling.
// so one guy failed after other two for the company and or agent road test,
// if the three or four sinoquebec people exchange the idea,
// the situation should be better
// here is an idea , reference only, any ideas are welcomed, thanks for positive people.
One Truck driver agent demanded to check the following things before road test
1, flash light (prepared), 2 triangle, 3,Rigistration of tractor and trailer, 4, instrument, 5, legal paper of transportaton company(check only)
6, stick of verification under the driver windows, outside
7, license plate, 8, PRP. 9 Heat Shield --!
1,INSPECTION BEFORE TO START
(1) 3 flares ok no offense (2) washer fluid ok ―! (no minor defect) (3) turn on flashers ( for cold inspect)
(4) unlock, in front of the truck, see the truck at level:truck straight
(5) see wheels: parallel ―O (no major defect), flasher functions―! (no minor defect), no oil leaks on the ground
(6) open the hood
2, RIGHT SIDE for the tractor (BeltFrameChokeLeafBonhommeTireRingNutsValveWheelLoupe) BFCLB TRNVW L
(1) Belt no loose, no crack―O (2) Frame no crack, no weld―O(3) Choke good tide―O, no leak―! (4) Leaf no crack, no weld, one master leaf or 25% small leaves cracked or missing O
(5) Bonhomme, U-bolt, 2 supports to leaf: good tide, good condition―O (6) Tire no balloon inside,outside,no foreign material in the tread―O; tread good condition―O, no flat―O
(7) Ring no crack no weld―O (8)all the Nuts good tide good condition, 1 or more missing or loose O (9) Valve, good condition―! (10) Wheel, no touch any parts of the body―O (11) Loupe, tide―!
3,LEFT SIDE for the tractor // LCG FCB FCLB TRNV W
( 1) Loupe, good tide―! (2) Compressor good tide―O (3) Governor good tide―! (4) Fluid in power steering reservoir: good level―! (5) Column tide from the anchorage and no loose―O (6) steering box good tide no leak―O (7) Frame, no crack no weld ―O (8) Choke good tide―O, no leak―! (9) Leaf: no crack no weld; one master leaf or 25% small leaves crack or missing O (10) Bonhomme, u-bolt, 2 supports to the leaf: good tide, good condition―O (11) Tire: no balloon inside,outside, no foreign in tread―O ; tread good condition―O; no flat―O (12) Ring, no crack no weld―O (13) all the Nuts:good tide,good condition, one or more missing or loose O (14) Valve good condition―! (15) Wheel: no touch any parts of the body―O 00:03:50
4, DRIVER SIDE (1) Mirror good tide―!
5, BETWEEN TRACTOR AND TRAILER( FC ) (1) Frame: no crack no weld―O (2) two Cross members good tide, good condition―!
6, BETWEEN THE AXLES OF THE TRACTOR IN THE LEFT SIDE without trailer: FPinHAnBolts FCLBA TRNVW
// Tractor Left: FifthHandlePinAnBoltFrameChokeLeavesBonhommesAirTireRingNutsValvesWheel
FHPin AnBolt FCLBA T R N V W
(1)(2) Fifth wheel: no crack, no damage good condition―O (3) Handle for unlock the fifth wheel and pin: good tide ―O (4) Anchorageon a sliding fifth wheel: good tide, good condition, 25% or more missing or not working O (5) all the Bolts to fix the fifth wheel: good tide, good condition, 20% or more missing or loosing O (6) Frame: no crack no weld―O (7) Choke in two side: good tide, no leak☺ (8) Leaves in two side: no crack, no weld ☺ (9) Bonhommes. U-bolt, supports of the leaf in two side: good tide good condition☺
(10) Air suspension no deflate good condition, a small air leak ! If Compressor can no maintain a minimum pressure of 90 psi O (11) ®Tires no balloon inside,outside, no foreign material in the tread, the tread in good condition, no flat☺ (12) ®Ring: no crack, no weld ☺ (13) ®all the Nuts good tide good condition ☺(14) ® Valves good condition ☺ (15) 4 Wheel: parallel, no touch any parts of the body☺
7, at the back of THE tractor // JawFrameCrossmemFlasherAir// JawFCFA
(1) Jaws : opened (before copling) ―O (2)(3) Frame: parallel, no crack no weld☺ (4) two Crossmembers: good tide good condition☺ (5) 4 Flashers function ☺ (6) 2 Air suspension: no deflate good condition ☺ (7)F (8)C
8, BETWEEN THE AXLES OF THE TRACTOR RIGHT DIMENSIONS withou trailer
// Tractor Right: FifthAnBoltFrameChokeLeavesBonhommesAirTireRingNutsValvesWheel
F AnBolt FCLBA TRN V W
(1) (2) Fifth wheel: no crack no damage☺ (3) Anchorage on a sliding fifth wheel: good tide good condition☺ (4) all the Bolts to fix the fifth wheel: good tide good condition☺ (5) Frame: no crack no weld, ☺ (6) Choke of two side: good tide no leak☺ (7) Leaves in two side: no crack, no weld☺ (8) Bonhommes,U-bolt, supports to leaves in two side: good tide good condition ☺ (9) Air suspension: no deflate good condition☺ (10) ®Tires: no balloon inside outside, no foreign material in the tread, the tread in good condition, no flat (kick 4 tires)☺ (11)® Ring: no crack no weld☺ (12) ®all the Nuts: good tide, good condition ☺ (13) ®Valves good condition ☺ (14) 4 Wheels : parallel no touch any parts of the body ☺ 00:11:00
9, FRAME OF TRUCK (1) Frame no crack no weld☺ (2) Mirror good tide☺ F M
// for tractor only, cold inspection finished, go to inside to start engine.
10, EMBARK IN THE TRUCK:
(1) switch key on (2) neutral ok, parking ok (3) wait indicator off, clutch, start engine (4) oil pressure goes up in 4 or 5 seconds (or indicate to 40) (5) on light/high beam (6) go down,engine is ok no leak in 2 sides , close hood (7) lock hood (8) high beam working-! (9) parking light ok -! (10) off high, flasher left (11) low beam work ,one no function! , both no function O (12) check flasher left (13) all lights on the left if 1 of them works minor (14) rear parking lights function no major (15) verifier the license plate light -! (16) say to the inspector, “verify the brake light”, apply the service brakes (17) turn flasher right, return at the back with the inspector (18) verify flashers and all the lights on the right (19) “tractor inspection outside finished”, go on the truck, turn off the flasher
INSIDE INSPECTION: (20) verify if the buzzer functions at 55 psi (1.5 low air pressure warning for service brakes) (21) release parking brake and to pump service brake, conform:the buzzer functions―! because the air pressure gages function (22) verify if the compressor reach and maintain a minimum of 90 psi, while the air goes up to maintain the foot on the service brake (1.6 component: compressor)
11, While AIR goes up:MENTION MAJOR AND MINOR:
(1) windshield: left: no crack―O (2) (windshield) right :no crack―! (3) test the wiper (4) left wiper working―O (5) right wiper working―! (6) washer: function in 2 sides ―!(7) steering wheel :good tide―O (8) horn functions―! (9) heating function―! (10) seat good tide―O (11) seat belt functions―O (12) left mirror: clean, adjust well, no crack no tarnished ―!(13) right mirror: clean, adjust well, no crack no tarnished ―!// Windshield Wiper Washer Wheel Horn Seat Belt Heat MM
12, MAKE AIR PRESSURE reading
(1) the pressure beyond 90 psi, no major on compressor, (1.6) (2) increase the rpm to 1500
(3) verify if governor stop compressor between 117 psi and 137 psi, if before 117 psi or after 137 psi , it's minor (1.1 pressure level the compressor stops operating)
13, While the AIR goes up Verify The PRESSURE GAUGES: (1)water temperature ok (2) oil pressure ok.(3) fuel ok. 4) air Pressure Go up (5) alternator ok
14, (4) compressor stop at 125 psi no defect,(1.1 component:governor)
release the service brake, stop(key off) the engine
15, APPLY THE SERVICE BRAKES:
(1) apply the service brake, and check how many psi loss, if loss less of 19 psi no defect; if loss more it is minor , ok (1.2 compressed air reservoirs)
(2) windows down, check air leak for 1 minute, if the loss between 3 and 6 psi !, if loss 6psi and more O; no air leak, pressure is stable, no defect (1.3 system)
(3) (reconnect,key on) clutch down and start engine, pump the service brake until 80 psi to check if the governor restart the compressor at 80 psi,confirms:air pressure goes up, the governor restart compressor, if need to pump less of 80 psi, minor (1.4)
16, check BRAKES and coupling
(1)(2)(3)(4) service brake for all vehicle: ok―O (5) (6)
(7) no major defect on the steering box.
// now copling, some company do not like to watch trailer from the window at the back,
// however, some other agent inspector do not mind if you see from back window
Couping (3 minutes) KingpinBetween5th//stopAfterFirstAxleOut, JawBackupwithHalfClutch, JerkWith1thGear,
Kingpinloggoin, Jawclosed, ElecRoses, Legup
(1) bring truck parallel fron of the trailer, make sure
put back gear bring trailer first axle out, stop.
go under the trailer make sure king ping between 5th wheel
// First step: position kingpin and jaw with first axle out and go to make sure under the trailer
(2) come inside truck, release truck brake
and put back gear, keep half clutch, go slowly under the trailer
and litsen noise. click---click, ( JawBackupwithHalfClutch )
then put 1th gear, give one or two jerk then put neutral, brake (parking brake of truck).
go out, make sure king pin log is go in and after go under trailer make sure jaw closed.
then electrical and air roses , then put up dolly legs ( LegUp )
// Second step: JawBackupwithHalfClutch, JerkWith1thGear,checkKingpinloggoin, Jawclosed, ElecRoses, Legup
// after copling, inspect following :
17, copling check (1) upplate and king pin no damaged no major(checked when couping), (2) jow cloed no major(checked when couplg)
(3) trailer Floor no major (4) trailer Cross member no major
18, check for trailer Pin FLB TRNVW Pin
19, check Behind the trailer
20, check lights for trailer no major in brake light and no major for rear parking light
flasher left, 4 flasher and flasher right check no minor, license plate light no minor
after coupling do left inspection whith flasher left.
and then at the back and right side with flasher left.
18-1, Inspect PinFLBTRN V W Pin for trailer left
19, Behind THE TRAILER
1. Bumper good tide―! (2) Flashers function (3) all the Pantures: good fix, good condition―offense 4) Open the door and check if the load will be firmly--offense (5) Close the door
rear parking lights function no major (4) verifier the license plate light -! (5) say to the inspector, “verify the brake light”, go to apply the service brakes, check 4Flashers function then turn flasher right, return at the back with the inspector
18-2 verify flashers and all the lights on the right
at the same time, check FLB TRN V W for trailer right
21, check BRAKES
(1) parking brake of trailer: ok―!
(2) parking brake of truck: ok―!
(3) manual brake of trailer : ok―!
(4) service brake is inspected
(5) move and check if the wheels of the trailer no jam, and if the steering box working on the left,on the right
(6) if the wheels of trailer don't move well !
(7)
The inspection is finished.
After practice on the road
uncoupling (2 minutes) LegDown, JawOpen, KingpinOut, UnlockRoses..
(1) Dolly Leg Down
(2) unlock king pin nob ( Jaw Open)
// come inside the tructor
// release truck brake only
// put 1th gear
// look at the rear mirror
// take axle come out, stop
// go out to make sure
(3) King Pin come out the 5th wheel
(4) Unlock air Roses and Electrical wire
The road test is finished.
( if couping over 10 minutes, failed.
if ones want to short the inspection time,
ones could say "ok" only to short for minor defect or major defect. ) |
|
[复制链接]
发表于 2008-1-23 22:45
楼主
大温华裔儿童在家弹琴 遭物业罚款超3万！法
蒙特利尔亲巴勒斯坦示威打砸商店烧汽车
兴旺超市本周特价
世纪超市本周特价